Search results for "Anaerobic Digestion"
showing 10 items of 134 documents
Anaerobic solubilisation of nitrogen from municipal solid waste (MSW)
2003
This paper reviews anaerobic solubilisation of nitrogen municipal solid waste (MSW) and the effect of current waste management practises on nitrogen release. The production and use of synthetically fixed nitrogen fertiliser in food production has more than doubled the flow of excessive nitrogenous material into the community and hence into the waste disposal system. This imbalance in the global nitrogen cycle has led to uncontrolled nitrogen emissions into the atmosphere and water systems. The nitrogen content of MSW is up to4.0% of total solids (TS) and the proteins in MSW have a lower rate of degradation than cellulose. The proteins are hydrolysed through multiple stages into amino acids …
Effects of solid–liquid separation on recovering residual methane and nitrogen from digested dairy cow manure
2006
The feasibility of optimizing methane and nitrogen recovery of samples obtained from farm biogas digester (35 degrees C) and post-storage tank (where digested material is stored for 9-12 months) was studied by separating the materials into different fractions using 2, 1, 0.5 and 0.25 mm sieves. Mass-balances revealed that digested material mainly consists of0.25 mm (60-69%) and2 mm (18-27%) fractions, while fractions between 2 and 0.2 mm made the rest. Incubation of solid fractions0.25 mm of digester material at 35 degrees C resulted in specific methane yields of 0.060-0.085 m(3)kg(-1) volatile solids (VS) during initial 30-50 d and 0.16-0.18 m(3)kg(-1)VS at the end of 340 d incubation. Sim…
Anaerobic on-site treatment of kitchen waste in combination with black water in UASB-septic tanks at low temperatures.
2006
Anaerobic on-site treatment of a mixture of black water and kitchen waste (BWKW) was studied using two-phased upflow anaerobic sludge blanket (UASB) septic tanks at the low temperatures of 20 and 10 degrees C. Black water (BW) was also treated alone as reference. The two-phased UASB-septic tanks removed over 95% of total suspended solids (TSS) and 90% of total chemical oxygen demand (COD(t)) from both BWKW (effluent COD(t) 171-199mg/l) and BW (effluent COD(t) 92-100mg/l). Also, little dissolved COD (COD(dis)) was left in the final effluents (BW 48-70mg/l; BWKW 110-113mg/l). Part of total nitrogen (N(tot)) was removed (BW 18% and BWKW 40%) and especially at 20 degrees C ammonification was ef…
Reliable method for assessing the COD mass balance of a submerged anaerobic membrane bioreactor (SAMBR) treating sulphate-rich municipal wastewater
2012
The anaerobic treatment of sulphate-rich wastewater causes sulphate reducing bacteria (SRB) and methanogenic archaea (MA) to compete for the available substrate. The outcome is lower methane yield coefficient and, therefore, a reduction in the energy recovery potential of the anaerobic treatment. Moreover, in order to assess the overall chemical oxygen demand (COD) balance, it is necessary to determine how much dissolved CH4 is lost in the effluent. The aim of this study is to develop a detailed and reliable method for assessing the COD mass balance and, thereby, to establish a more precise methane yield coefficient for anaerobic systems treating sulphate-rich wastewaters. A submerged anaer…
Precipitation assessment in wastewater treatment plants operated for biological nutrient removal: a case study in Murcia, Spain.
2009
The Murcia Este Wastewater Treatment Plant is the largest wastewater treatment plant in Murcia (Spain). The plant operators have continuously found pipe blockage and accumulation of solids on equipment surfaces during the anaerobic digestion and post-digestion processes. This work studies the precipitation problems in the Murcia Este Wastewater Treatment Plant in order to locate the sources of precipitation and its causes from an exhaustive mass balance analysis. The DAF thickener and anaerobic digester mass balances suggest that most of the polyphosphate is released during excess sludge thickening. Despite the high concentrations achieved in the thickened sludge, precipitation does not occ…
Sewage sludge acidogenic fermentation for organic resource recovery towards carbon neutrality: an experimental survey testing the headspace influence
2022
Volatile fatty acids (VFAs) produced by acidogenic digestion of sewage sludge are very interesting bio-products which can contribute to carbon neutrality of wastewater treatment plants. Studies on the production of VFAs from sewage sludge from fermenters with membrane are limited. In view of above, VFAs from a fermenter pilot plant equipped with a membrane bioreactor and fed with real sewage sludge has been monitored. The effect of headspace volume (HdV) on VFA production was studied for the first time to elucidate the optimal operation conditions. Specifically, three fermenter HdV values (namely, 20, 40 and 60% of the total volume) have been investigated. Results revealed that the HdV of 2…
Two-stage anaerobic digestion of tomato, cucumber, common reed and grass silage in leach-bed reactors and upflow anaerobic sludge blanket reactors
2010
Abstract Anaerobic digestion of tomato, cucumber, common reed and grass silage was studied in four separate two-stage reactor configuration consisting of leach bed reactor (LBR) and upflow anaerobic sludge blanket reactor (UASB). LBR studies showed that COD solubilization for cucumber and grass silage was higher (50%) than tomato (35%) and common reed (15%). Results also showed that 31–39% of initial TKN present in tomato and cucumber was solubilized in the leachates and 47–54% of the solubilized TKN was converted to NH4-N. The corresponding values for common reed and grass silage were 38–50% and 18–36%, respectively. Biomethanation of the leachates in UASB reactors resulted in methane yiel…
Sewage sludge management for phosphorus recovery as struvite in EBPR wastewater treatment plants
2008
The influence of separate and mixed thickening of primary and secondary sludge on struvite recovery was studied. Phosphorus precipitation in the digester was reduced from 13.7 g of phosphorus per kg of treated sludge in the separate thickening experiment to 5.9 in the mixed thickening experiment. This lessening of the uncontrolled precipitation means a reduction of the operational problems and enhances the phosphorus availability for its later crystallization. High phosphorus precipitation and recovery efficiencies were achieved in both crystallization experiments. However, mixed thickening configuration showed a lower percentage of phosphorus precipitated as struvite due to the presence of…
Struvite formation from the supernatants of an anaerobic digestion pilot plant
2009
This work studied the influence of the characteristics of the supernatants on the struvite precipitation process. Eighteen experiments with the supernatants generated in an anaerobic digestion pilot plant were performed in a stirred reactor. In order to obtain the pH control during the crystallization process, a Fuzzy Logic based controller was used. High phosphorus precipitation and recovery efficiencies were obtained. The composition of the supernatants was analyzed in order to study its influence on the solids formed from those solutions. The presence of calcium reduced the percentage of phosphorus precipitated as struvite leading to the formation of amorphous calcium phosphate (ACP), wh…
Optimisation of sludge line management to enhance phosphorus recovery in WWTP
2008
The management of the sludge treatment line can be optimized to reduce uncontrolled phosphorus precipitation in the anaerobic digester and to enhance phosphorus recovery in WWTP. In this paper, four operational strategies, which are based on the handling of the prefermented primary sludge and the secondary sludge from an EBPR process, have been tested in a pilot plant. The separated or mixed sludge thickening, the use of a stirred contact tank and the elutriation of the thickened sludge are the main strategies studied. Both the reduction of phosphorus precipitation in the digester and the supernatant suitability for a struvite crystallization process were assessed in each configuration. The…