Search results for "Contactor"
showing 10 items of 12 documents
Comparing the efficiency of wastewater treatment technologies through a DEA metafrontier model
2011
Abstract The assessment of economic and technical efficiency is a useful tool to select the most appropriate technology for wastewater treatment. However, traditional models require that the units being assessed operate with the same technology. To overcome this limitation, we investigate the viability of using a non-concave metafrontier approach that is based on data envelopment analysis (DEA) to calculate the techno-economic efficiency and technological gap ratios (TGRs) of wastewater treatment plants (WWTPs) operating with non-homogeneous technologies. The model is applied to a sample of 99 Spanish WWTPs, encompassing four alternative technologies: activated sludge; aerated lagoon; trick…
Mass transfer and hydrodinamic characteristics of a high aspect ratio self-ingesting reactor for gas-liquid operations
2007
Abstract The mass transfer performance of a gas–liquid self-ingesting stirred reactor is reported both for coalescing and non-coalescing systems. The vessel features are a high aspect ratio and a rather narrow multiple-impeller draft tube, through which the gas phase is ingested and led down to the vessel bottom, where it is finely dispersed into the liquid rising in the annular portion of the vessel. Comparison is made between k L a values determined by several variants of the dynamic method, among which pure oxygen absorption in a previously de-gassed liquid phase. Results show that the gas–liquid mass transfer coefficient values obtained with the last approach are remarkably larger than …
Influence of the tip effect of a carbon nanostructure on low current electrical arc initiation
2009
During their setting off, circuit breakers and vacuum switch devices are accompanied by an electric arc whose physical and chemical properties are governed by emissive current sites at the cathode surface called cathode spots. Assuming the continuity of the current on the cathode surfaces, the cathode spots contribute to supply the electrical arc by electron emission and material ejection. Thus they cause erosion on the contact electrodes inducing a dysfunction of contactors. The apparition of these cathode spots is due essentially to dust particles and surface irregularities at different scales. This experimental work represents a contribution to the understanding of the electrical arc beh…
A Friendly-Biological Reactor SIMulator (BioReSIM) for studying biological processes in wastewater treatment processes
2014
Biological processes for wastewater treatments are inherently dynamic systems because of the large variations in the influent wastewater flow rate, concentration composition and the adaptive behavior of the involved microorganisms. Moreover, the sludge retention time (SRT) is a critical factor to understand the bioreactor performances when changes in the influent or in the operation conditions take place. Since SRT are usually in the range of 10-30 days, the performance of biological reactors needs a long time to be monitored in a regular laboratory demonstration, limiting the knowledge that can be obtained in the experimental lab practice. In order to overcome this lack, mathematical model…
Nitrogen recovery using a membrane contactor: Modelling nitrogen and pH evolution
2020
[EN] A hollow fibre membrane contactor has been applied for nitrogen recovery from anaerobic digestion supernatant at different operating conditions obtaining nitrogen recovery efficiencies over 99 %. A mathematical model able to represent the time evolution of pH and nitrogen concentration during the recovery process is presented in this paper. The developed model accurately reproduced the results obtained in 26 experiments carried out at different pH values (from 9 to 11), temperatures (from 25 to 35 degrees C), membrane surfaces (from 1.2 to 2.4 m(2)) and feed flow rates (from 0.33 x 10(-5) to 5.83 x 10(-5) m(3)/s) predicting the variations in nitrogen recovery rates measured at the diff…
Recuperación de metano disuelto en el efluente de un reactor anaerobio de lecho expandido mediante contactores de membrana
2017
La emisión de gases de efecto invernadero (GEI) a la atmósfera supone uno de los problemas medioambientales más importantes en la actualidad, debido a su relación con el calentamiento global y el cambio climático. En este sentido, uno de los GEI más relevantes es el metano, con un potencial de calentamiento global 28 veces superior al del dióxido de carbono. El sector del tratamiento de aguas residuales contribuye a las emisiones de metano, siendo de especial relevancia los tratamientos anaerobios que se llevan a cabo a temperatura ambiente. En estos sistemas, una parte del metano generado puede encontrarse disuelto en el efluente del proceso, debido al aumento de la solubilidad del metano …
Economic analysis of the scale-up and implantation of a hollow fibre membrane contactor plant for nitrogen recovery in a full-scale wastewater treatm…
2021
[EN] Nitrogen recovery technologies such as the hollow fibre membrane contactor are now being developed. However, an economic analysis is needed prior to their full-scale application in wastewater treatment plants. The aim of this study was to analyse the economic and environmental aspects of scaling-up this method. To achieve it, a full-scale 40,000 m3·day¿1-wastewater treatment plant influent flow rate was simulated jointly with a membrane contactor plant to evaluate the minimum costs of optimum operating conditions of membrane contactors (pH, feed flow rate and membrane surface). The optimum conditions for treating 600 m3·day¿1 of reject water was found to be 10 pH, 0.08 m3·s¿1 feed flow…
Simultaneous application of vacuum and sweep gas in a polypropylene membrane contactor for the recovery of dissolved methane from water
2021
Abstract Vacuum and nitrogen as sweep gas were used simultaneously (combination mode) to generate the driving force in a microporous polypropylene membrane contactor for the recovery of dissolved methane from water. Experiments were carried out under different liquid flow-rates (5.0–28.0 L h−1), N2 flow-rates (0.5–1.5 L h−1) and vacuum pressures (0–480 mbar). The maximum removal efficiency of methane was >90% at moderate values of gas-to-liquid ratios (G/L) and vacuum of 0.2 and ≤ 200 mbar, respectively. Removal efficiencies obtained in combination mode were usually higher than when using vacuum or sweep gas, separately. To achieve a methane content >35% in the recovered gas, G/L values low…
Comparing the dynamic performance of wastewater treatment systems: A metafrontier Malmquist productivity index approach
2015
The assessment of productivity change of wastewater treatment plants (WWTPs) is essential to improve the performance over time of the facilities evaluated. This study assessed and compared the productivity growth of WWTPs operating with non-homogeneous technologies. The metafrontier Malmquist productivity index (MMPI) was computed for a sample of 99 WWTPs encompassing 4 alternative technologies: activated sludge (AS), aerated lagoon (AL), trickling filter (TF) and rotating biological contactor (BD). The results indicated that, on average, WWTPs with AS and BD exhibited better performance over time than WWTPs with AL and TF. The MMPI indicates that, over the period 2007-2009, the productivit…
PMRs Utilizing Non–Pressure-Driven Membrane Techniques
2018
In the present chapter it is shown how photocatalytic membrane reactors utilizing membrane processes, which are not pressure driven, can exploit various mechanisms to obtain a substantial improvement of the process. The fundamentals of this particular type of membrane reactors are reviewed including the effects of the most important parameters and the methods and rules of coupling photocatalysis and membrane separation. The survey of the studies on photocatalytic membrane reactors (PMRs) utilizing pervaporation, dialysis, membrane contactors and membrane distillation offers the opportunity of discussing the advantages with respect to PMRs adopting pressure driven membrane processes. Indeed,…