Search results for "Pulp and paper industry"
showing 10 items of 406 documents
Extreme thermophilic (70°C), VFA-fed UASB reactor: performance, temperature response, load potential and comparison with 35 and 55°C UASB reactors
1999
Abstract The paper evaluates the reactor performance, load potential and temperature response of a 70°C, VFAs-fed UASB reactor, seeded with mesophilic granular sludge. Batch experiments were, in addition, conducted to assess the effect of temperature on the achievable residual VFAs in the 70°C effluent. The performance of similarly-fed and seeded 35 and 55°C UASB reactors was also tested. At a short HRT (2–3 h) and a moderate VLR of 12–20 g COD l−1 d−1, the 70°C UASB achieved 66–74% VFAs removal (acetate and butyrate 84–90%, propionate
Design of nutrient removal activated sludge systems
2003
A mechanistic mathematical model for nutrient and organic matter removal was used to describe the behavior of a nitrification denitrification enhanced biological phosphorus removal (NDEBPR) system. This model was implemented in a user-friendly software DESASS (design and simulation of activated sludge systems). A 484-L pilot plant was operated to verify the model results. The pilot plant was operated for three years over three different sludge ages. The validity of the model was confirmed with data from the pilot plant. Also, the utility of DESASS as a valuable tool for designing NDEBPR systems was confirmed.
Biofiltration of ethylbenzene vapours: influence of the packing material.
2006
In order to investigate suitable packing materials, a soil amendment composed of granular high mineralized peat (35% organic content) locally available has been evaluated as carrier material for biofiltration of volatile organic compounds in air by comparison with a fibrous peat (95% organic content). Both supports were tested to eliminate ethylbenzene from air streams in laboratory-scale reactors inoculated with a two-month conditioned culture. In pseudo-steady state operation, experiments at various ethylbenzene inlet loads (ILs) were carried out. Maximum elimination capacity of about 120 g m(-3) h(-1) for an IL of 135 g m(-3) h(-1) was obtained for the fibrous peat. The soil amendment re…
Characterization and Reprocessing of Greenhouse Films.
2001
Films for greenhouses are an attractive source of post-consumer plastic materials because they are mainly made of polyethylene and can be easily collected in large amounts in small zones. The types of polymers for this application are, however, increasing and the films contain not only additives and stabilisers, but also fertiliser and pesticide residues. Finally, the extent of photooxidative degradation undergone during the use can strongly influence the recycling operations and the final properties of the secondary material. In this work, a complete characterisation of post-consumer films for greenhouses has been carried out and the properties of the recycled material have been correlated…
Virucidal effect of high power ultrasound combined with a chemical sanitizer containing peroxyacetic acid for water reconditioning in the fresh-cut i…
2015
The use of chlorine-based sanitizers is widespread throughout the fresh produce industry in the process water to maintain microbial safety of produce, avoid cross-contamination and recycle water. In this study, alternative disinfection technologies were investigated due to the negative reports showing chlorine instability in the presence of organic matter and the undesirable by-product residues. Tsunami ® (15.2% peroxyacetic acid and 11.2% hydrogen peroxide) and high-power ultrasound (HPU, 0.56 kW/l, 20 kHz), alone or in combination, were evaluated in lettuce process water analyzing their ability to reduce MNV during either produce washing or water recycling. PAA concentrations of 6.4, 12.8…
Design of the Biotechnological System for the Cultivation of a Polysaccharide-Producing Microorganism and Metabolites Separation
1970
This paper presents a design of the biotechnological system established for the cultivation of a polysaccharide-producing microorganism and the separation of the polysaccharide together with other metabolites. The strain used is a halophilic archaeon called Haloferax mediterranei (Mironescu et al., 2003). On designing the biotechnological system, some requirements are important: The recipients and the pipes must be resistant to the corrosion action of the cultivation substrate very rich in NaCl (125 to 150 g/l); A command and control system for pH, temperature and substrate and inoculum feeding is necessary; A system for monitoring dissolved oxygen and gases evacuated from the bioreactor (O…
Environmentally sustainable production of cellulose-based superabsorbent hydrogels
2006
The development of new products and materials, especially those which are non-petrolchemical reserves and based on renewable organic resources, using innovative sustainable processes is nowadays of increasing interest and deserves the attention of both academic and industrial research. Cellulose and its derivatives, as renewable organic resources, have been used to synthesize novel superabsorbent hydrogels. Although the production of cellulose is one of the causes connected to deforestation, the production of suitably engineered cellulose superabsorbent hydrogel materials has been proposed to preserve water in typically arid areas in the world. Paradoxically, divinylsulfone (DVS), a small d…
Behavior of carbohydrate-based material in black liquor during heating
2004
One industrial softwood Kraft black liquor was heat-treated (at 175 ?C and 190 ?C for 15-60 min) together with laboratory-made soda-AQ (wheat straw and reed canary grass) and Kraft (reed canary grass) black liquors (at 190 ?C for 30 min). The feedstock black liquors were characterized with respect to their polysaccharide (mainly xylem) and aliphatic carboxylic acid contents before and after the heat treatments. It was noted that, due to the higher amount of polysaccharides in the non-wood black liquors (8.2-16.6% of d.s) compared to that in the softwood black liquor (1.4% of d.s), the heat treatment in the former case resulted in a 5-30% increase in the amount of aliphatic acids formed by v…
Screening pretreatment methods to enhance thermophilic anaerobic digestion of pulp and paper mill wastewater treatment secondary sludge
2013
Abstract The effect of hydrothermal (150 °C for 10 min and 70 °C for 40 min), enzymatic (Accelerase 1500, 0.07 g/g volatile solids (VS)), ultrasound (45 kHz for 30 min) and chemical pretreatments (HNO3 at pH 3 and NaOH at pH 12) alone or in combination on the chemical composition and methane yield of the pulp and paper mill secondary sludge was studied in batch assays at 55 °C. In total, 12 different pretreatment combinations were compared. Chemical analyses showed that all pretreatments except for HNO3 and ultrasound pretreatments improved the organic matter solubilization. Among the studied pretreatments, hydrothermal (150 °C, 10 min) pretreatment alone or in combination with enzymatic an…
Bleaching of color of kraft pulp mill effluents and natural organic matter in lakes
2002
In situ changes in the color of lake water and biologically treated kraft pulp mill effluents mixed in lake water were examined in three lakes. In 1.7 m3 enclosures, the color (400700 g Pt·m3) of the mixture of pulp mill effluent and lake water remained similar for 4 months in darkness, whereas exposure to solar radiation resulted in 1742% bleaching of color. During the summer stratification of a humic lake, the color (160 g Pt·m3) of hypolimnetic water remained similar to that found during spring turnover, but the color of epilimnion decreased 13%. The measured rates of photochemical bleaching of color by solar radiation could explain the decrease of epilimnetic color. Attenuation of …