Search results for "paper industry"
showing 10 items of 413 documents
Electrochemical technology for the treatment of real washing machine effluent at pre-pilot plant scale by using active and non-active anodes
2018
Abstract Real effluent of washing machine is one of the major sources of microplastics and fabrics in municipal and surface water. The effluents constitute large volume of wastewater with different surfactants since every household and industries nowadays use washing machine rather than traditional hand washing. In this work, a real effluent of washing machine was treated by electrooxidation (EO) in a pre-pilot plant scale electrochemical flow reactor using active (Ti/Pt) or non-active (boron doped diamond (BDD)) anodes and Ti cathode. The effect of anode material (Ti/Pt or BDD) and the applied current density (16.6, 33.3 and 66.6 mA cm−2) on the decay of the organic matter, in terms of che…
Hydrothermal liquefaction of waste biomass in stirred reactors: One step forward to the integral valorization of municipal sludge
2020
Abstract Hydrothermal liquefaction (HTL) of municipal sludge (MS) was performed at 350 °C for 30 min (subcritical water) and at 400 °C for 0 min (supercritical water) at fixed kinetic severity (LogR0 = 8.9) in static and stirred batch reactors to study the effect of the flow regime on the energy recovery (ER) of the process and on the quality of the products. With adopted experimental procedures it was possible to reduce to less than 10% the yield of lost organic compounds, termed volatiles (VT), and to collect and quantify a liquid hydrocarbon fraction (HC) separated from the biocrude (BC). The highest value of the HC yield, 25% w/w, was obtained in supercritical conditions. The C content …
Exploring the limits of anaerobic biodegradability of urban wastewater by AnMBR technology
2018
[EN] Anaerobic membrane bioreactors (AnMBRs) can achieve maximum energy recovery from urban wastewater (UWW) by converting influent COD into methane. The aim of this study was to assess the anaerobic biodegradability limits of urban wastewater with AnMBR technology by studying the possible degradation of the organic matter considered as non-biodegradable as observed in aerobic membrane bioreactors operated at very high sludge retention times. For this, the results obtained in an AnMBR pilot plant operated at very high SRT (140 days) treating sulfate-rich urban wastewater were compared with those previously obtained with the system operating at lower SRT (29 to 70 days). At 140 days SRT the …
Extreme thermophilic (70°C), VFA-fed UASB reactor: performance, temperature response, load potential and comparison with 35 and 55°C UASB reactors
1999
Abstract The paper evaluates the reactor performance, load potential and temperature response of a 70°C, VFAs-fed UASB reactor, seeded with mesophilic granular sludge. Batch experiments were, in addition, conducted to assess the effect of temperature on the achievable residual VFAs in the 70°C effluent. The performance of similarly-fed and seeded 35 and 55°C UASB reactors was also tested. At a short HRT (2–3 h) and a moderate VLR of 12–20 g COD l−1 d−1, the 70°C UASB achieved 66–74% VFAs removal (acetate and butyrate 84–90%, propionate
Design of nutrient removal activated sludge systems
2003
A mechanistic mathematical model for nutrient and organic matter removal was used to describe the behavior of a nitrification denitrification enhanced biological phosphorus removal (NDEBPR) system. This model was implemented in a user-friendly software DESASS (design and simulation of activated sludge systems). A 484-L pilot plant was operated to verify the model results. The pilot plant was operated for three years over three different sludge ages. The validity of the model was confirmed with data from the pilot plant. Also, the utility of DESASS as a valuable tool for designing NDEBPR systems was confirmed.
Biofiltration of ethylbenzene vapours: influence of the packing material.
2006
In order to investigate suitable packing materials, a soil amendment composed of granular high mineralized peat (35% organic content) locally available has been evaluated as carrier material for biofiltration of volatile organic compounds in air by comparison with a fibrous peat (95% organic content). Both supports were tested to eliminate ethylbenzene from air streams in laboratory-scale reactors inoculated with a two-month conditioned culture. In pseudo-steady state operation, experiments at various ethylbenzene inlet loads (ILs) were carried out. Maximum elimination capacity of about 120 g m(-3) h(-1) for an IL of 135 g m(-3) h(-1) was obtained for the fibrous peat. The soil amendment re…
Characterization and Reprocessing of Greenhouse Films.
2001
Films for greenhouses are an attractive source of post-consumer plastic materials because they are mainly made of polyethylene and can be easily collected in large amounts in small zones. The types of polymers for this application are, however, increasing and the films contain not only additives and stabilisers, but also fertiliser and pesticide residues. Finally, the extent of photooxidative degradation undergone during the use can strongly influence the recycling operations and the final properties of the secondary material. In this work, a complete characterisation of post-consumer films for greenhouses has been carried out and the properties of the recycled material have been correlated…
Virucidal effect of high power ultrasound combined with a chemical sanitizer containing peroxyacetic acid for water reconditioning in the fresh-cut i…
2015
The use of chlorine-based sanitizers is widespread throughout the fresh produce industry in the process water to maintain microbial safety of produce, avoid cross-contamination and recycle water. In this study, alternative disinfection technologies were investigated due to the negative reports showing chlorine instability in the presence of organic matter and the undesirable by-product residues. Tsunami ® (15.2% peroxyacetic acid and 11.2% hydrogen peroxide) and high-power ultrasound (HPU, 0.56 kW/l, 20 kHz), alone or in combination, were evaluated in lettuce process water analyzing their ability to reduce MNV during either produce washing or water recycling. PAA concentrations of 6.4, 12.8…
Design of the Biotechnological System for the Cultivation of a Polysaccharide-Producing Microorganism and Metabolites Separation
1970
This paper presents a design of the biotechnological system established for the cultivation of a polysaccharide-producing microorganism and the separation of the polysaccharide together with other metabolites. The strain used is a halophilic archaeon called Haloferax mediterranei (Mironescu et al., 2003). On designing the biotechnological system, some requirements are important: The recipients and the pipes must be resistant to the corrosion action of the cultivation substrate very rich in NaCl (125 to 150 g/l); A command and control system for pH, temperature and substrate and inoculum feeding is necessary; A system for monitoring dissolved oxygen and gases evacuated from the bioreactor (O…
Environmentally sustainable production of cellulose-based superabsorbent hydrogels
2006
The development of new products and materials, especially those which are non-petrolchemical reserves and based on renewable organic resources, using innovative sustainable processes is nowadays of increasing interest and deserves the attention of both academic and industrial research. Cellulose and its derivatives, as renewable organic resources, have been used to synthesize novel superabsorbent hydrogels. Although the production of cellulose is one of the causes connected to deforestation, the production of suitably engineered cellulose superabsorbent hydrogel materials has been proposed to preserve water in typically arid areas in the world. Paradoxically, divinylsulfone (DVS), a small d…