Search results for "Drying"

Drying kinetics and physico-chemical quality of mango slices

2019

Mango (Mangifera indica L.) is an important tropical fruit consumed worldwide and grown in Italy only in Sicily, where the areas of the Tyrrhenian coast have proved to be suitable to produce valuable fruits. Mango fruit has a pleasant aroma and taste, which are important qualities for consumer’s sensorial acceptance. However, they are highly perishable, prone to progressive undesired changes if stored untreated, resulting in around 25% postharvest losses, which is further increased during storage and transportation. An alternative for reducing the above-mentioned undesired changes is the dehydration of the cut fruit, which reduce the fruit water activity, thereby avoiding the deteriorative …

Increasing the drying efficiency of cylinder drying

2011

This PhD Thesis concentrates on paper drying: first on the drying rate in a cylinder covered with fabric, enhanced using hot air impingement through the fabric, and its potential effects on paper quality, and second, on the heat transfer rate from hot steam to paper through the cylinder shell. Cylinder drying is a drying method where a heated surface in contact with paper causes water removal from the latter by evaporation. Impingement through the fabric of hot air has been suggested to cause increase in the water removal and drying of paper. Increase in the drying rate by impingement of hot air was confirmed by laboratory tests and by simulations. In laboratory tests the increase in the dr…

Encapsulation of Vitamins A and E as Spray-Dried Additives for the Feed Industry

2020

Encapsulated fat-soluble powders containing vitamin A (VA) and E (VE) were prepared as a feasible additive for extruded feed products. The effect of the encapsulating agents (Capsul-CAP&reg

Chemical composition and microencapsulation suitability of sumac (Rhus coriaria L.) fruit extract

2021

Sumac (Rhus coriaria L.), a spice obtained by grinding whole sumac berries, is a complex natural product with a plethora of biological activities that can be favorably explored in nutraceutical and pharmaceutical fields. Sicilian sumac is herein chemically investigated by means of a combined NMR/HR MS-based profiling. A hydroalcoholic extract was prepared and its complexity unraveled following fractionation in an alcoholic and an aqueous fraction. The 1H-NMR spectrum of this latter fraction was dominated by the signals of gallic acid and its derivatives, whereas HR MS and HR MS/MS analyses highlighted the diversity in malic acid derivatives. Gallotannins and galloyl flavonol glycosides with…

Microencapsulation of Salmonella-Specific Bacteriophage Felix O1 Using Spray-Drying in a pH-Responsive Formulation and Direct Compression Tableting o…

2019

The treatment of enteric bacterial infections using oral bacteriophage therapy can be challenging since the harsh acidic stomach environment renders phages inactive during transit through the gastrointestinal tract. Solid oral dosage forms allowing site-specific gastrointestinal delivery of high doses of phages, e.g., using a pH or enzymatic trigger, would be a game changer for the nascent industry trying to demonstrate the efficacy of phages, including engineered phages for gut microbiome modulation in expensive clinical trials. Spray-drying is a scalable, low-cost process for producing pharmaceutical agents in dry powder form. Encapsulation of a model Salmonella-specific phage (Myoviridae…

Antioxidant activity and sensory attributes of tomatoes dehydrated by combination of microwave and convective heating

2013

Tomato halves were dried in a combined microwave-hot air system. Drying experiments were carried out by applying the microwave energy (0.5 W/g) at the beginning of the dehydration process (for 2 and 3.5 hours); simultaneously combining microwave (0.25 W/g) with convective hot-air drying (70°C); and by applying only convective hot air at 70°C. The combined microwave-hot air heating reduced significantly the drying time (up to 50 %), if compared with the only convective system. Simultaneous convective and microwave heating allowed besting preserving antioxidant activity of dried tomatoes, by minimizing lycopene and phenols losses, while ensuring satisfied texture characteristics and less perc…

Effects of heating, drying and straining on the relaxation and tensile properties of wet paper

2014

Deficit irrigation and maturation stage influence quality and flavonoid composition of ‘Valencia’ orange fruit

2016

BACKGROUND:Effects of continuous deficit irrigation (DI) and partial rootzone drying (PRD) treatments (50%ETc) in comparison with full irrigation (CI, 100% ETc) were investigated during ‘Valencia’ orange fruit maturation. Ultra-high-performance liquid chromatography/high-resolutionmass spectrometry was used to quantify hesperidin, narirutin, tangeritin, nobiletin, didymin and neoeriocitrin in the fruit juice and peel. RESULTS: No significant effect of irrigation was found on yield, juice soluble solids or acidity. Juice color was not influenced by irrigation or harvest date, whereas peel color increased during maturation and was more pronounced in CI and PRD fruits. Juice acidity reached a …

Optimization of Spray-Drying Process of

2019

Jerusalem artichoke is an important natural matrix for inulin production. In this experiment, response surface methodology (RSM) was employed to optimize the spray-drying parameters in order to determine the maximal inulin yield. For this study, three independent variables (heating temperature (Tª, 110–120 °C), creep speed (V, 18–22 rpm) and pressure (P, 0.02–0.04 MPa)) were used in the experimental design. Using the Box–Behnken design, the optimal parameters obtained were: drying temperature 114.6 °C, creep speed 20.02 rpm, and pressure: 0.03 MPa. The inulin yield, water content and particle size of inulin obtained by spray-drying and freeze-drying were compared. In this regard, the spray-…

Dry cherry tomato: innovation from studies on isotherms

2014

The drying of vegetables is a very ancient practice for food preservation still in use nowadays. Tomatoes cut into two parts, added with salt and dried are an important element of the food tradition in south of Italy. The tomato’s drying in Sicily is still carried out with a sun-drying process, with an empiric method. The final product obtained has a high quality which it is not homogeneous. In addition to dried products, the market offer even semidry products, to limit the loss of the nutritional characteristics of the dried product. The semidry product is a special category of dehydrated products that have a residual moisture content about 30%; for this reason, nutritional product charact…