Search results for "Pilot plant."

Reverse electrodialysis: advanced modelling and scale-up

In vivo application and dynamics of lactic acid bacteria for the four-season production of Vastedda-like cheese.

2014

article Twelve lactic acid bacteria (LAB), previously selected in vitro (Gaglio et al., 2014), were evaluated in situ for their potential to act as starter cultures for the continuous four-season production of Vastedda-like cheese, made with raw ewes' milk. The strains belonged to Lactobacillus delbrueckii, Lactococcus lactis subsp. cremoris, Leuconostoc mesenteroides subsp. mesenteroides and Streptococcus thermophilus .L AB werefirst inoculated in multiple-strain combinations on the basis of their optimal growth temperatures in three process conditions which differed for milk treatment and medium for strain development: process 1, growth of strains in the optimal synthetic media and pasteu…

Influence of total solids concentration on membrane permeability in a submerged hollow-fibre anaerobic membrane bioreactor.

2012

The main aim of this work was to study the influence of the mixed liquor total solids (MLTS) concentration on membrane permeability (K 20) in a submerged anaerobic membrane bioreactor (SAnMBR) pilot plant, which is equipped with industrial hollow-fibre membranes and treats urban wastewater. This pilot plant was operated at 33°C and 70 days of SRT. Two different transmembrane fluxes (13.3 and 10 LMH) were tested with a gas sparging intensity of 0.23 Nm 3 m -2 h -1 (measured as Specific Gas Demand referred to membrane area). A linear dependence of K 20 on MLTS concentration was observed within a range of MLTS concentration from 13 to 32 g L -1 and J 20 of 10 LMH. K 20 was maintained at sustai…

Modeling of PAH elimination by adiabatic steam stripping and intraparticle desorption

2003

The decontamination process of solids loaded with PAH in a pilot plant is modeled. This process is separated into two main stages: fast steam stripping at the entrance of the separation tube and the subsequent slow desorption of PAH from the interior of the soil particles. The stripping process also occurs in two stages: fast diffusion controlled saturation of the partial pressures followed by the heat transfer controlled evaporation. The phase diagram of PAH/water is constructed using both the microscopic model and empirical relationships for systems with wide miscibility gaps. The numerical basis for the calculations describing desorption from the soil particles is discussed. The model fo…

Microbial strategies to improve the final quality of traditional Sicilian cheeses

Fermentation and elutriation of primary sludge: Effect of SRT on process performance

2007

Abstract A primary sludge fermentation–elutriation pilot plant was operated using in-line and side-stream schemes. The influence of solids retention time, recirculation sludge flow-rate and solids concentration on the fermentation–elutriation process performance has been assessed in this paper. The use of high elutriation flows (12% of influent flow) improved the volatile fatty acids (VFA) concentration in the effluent stream. Suspended solids removal efficiency decreased in the primary settler when the solids retention time (SRT) was increased from 4 to 8 days. Disintegration step during hydrolysis process was pointed out as the main reason for that decrease. Maximum VFA productions were a…

Comparison between hybrid moving bed biofilm reactor and activated sludge system: a pilot plant experiment

2010

The paper presents the comparison between the traditional activated sludge system (AS) and a hybrid moving bed biofilm reactor (HMBBR). In particular, an experimental campaign has been carried out at the WWTP in Palermo (Italy), on a pilot plant consisting of two pre-anoxic schemes. The aerated tank of the HMBBR line was filled with suspended carriers (AnoxKaldnes™ K1), with a 30% filling ratio. The hydraulic load of the HMBBR line was increased up to two times the AS one. Further, in order to distinguish the additional contribution of the attached biomass for the HMBBR system, in the two lines the Mixed Liquor Suspended Solids (MLSS) was maintained as equal as possible. The monitoring peri…

Calibration and simulation of ASM2d at different temperatures in a phosphorous removal pilot plant

2006

In this work, an organic and nutrient removal pilot plant was used to study the temperature influence on phosphorus accumulating organisms. Three experiments were carried out at 13, 20 and 24.5 degrees C, achieving a high phosphorus removal percentage in all cases. The ASM2d model was calibrated at 13 and 20 degrees C and the Arrhenius equation constant was obtained for phosphorus removal processes showing that the temperature influences on the biological phosphorus removal subprocesses in a different degree. The 24.5 degrees C experiment was simulated using the model parameters obtained by means of the Arrhenius equation. The simulation results for the three experiments showed good corresp…

Evaluation of biomass activity and wastewater characterization in a UCT-MBR pilot plant by means of respirometric techniques

2011

Abstract Over the last two decades, Membrane Bioreactors (MBRs) emerged even more for wastewater treatment, ensuring high removal efficiencies as well as very small footprint requirements. Indeed, in this kind of process, a modification in biomass activity and viability can exist compared to that of a CAS process. In this context, respirometric analysis represents a reliable tool in order to evaluate the actual biomass kinetic parameters, to insert in mathematical models in the design phase, as well as to monitor the biomass viability, especially when these processes are operated with high SRT values. The paper presents some results of respirometric techniques applied for the characterisati…

Electrochemical technology for the treatment of real washing machine effluent at pre-pilot plant scale by using active and non-active anodes

2018

Abstract Real effluent of washing machine is one of the major sources of microplastics and fabrics in municipal and surface water. The effluents constitute large volume of wastewater with different surfactants since every household and industries nowadays use washing machine rather than traditional hand washing. In this work, a real effluent of washing machine was treated by electrooxidation (EO) in a pre-pilot plant scale electrochemical flow reactor using active (Ti/Pt) or non-active (boron doped diamond (BDD)) anodes and Ti cathode. The effect of anode material (Ti/Pt or BDD) and the applied current density (16.6, 33.3 and 66.6 mA cm−2) on the decay of the organic matter, in terms of che…