Search results for "stallis"

Determination of impurity distributions in ingots of solar grade silicon by neutron activation analysis

2017

AbstractIn a series of crystallization experiments, the directional solidification of silicon was investigated as a low cost path for the production of silicon wafers for solar cells. Instrumental neutron activation analysis was employed to measure the influence of different crystallization parameters on the distribution of 3d-metal impurities of the produced ingots. A theoretical model describing the involved diffusion and segregation processes during the solidification and cooling of the ingots could be verified by the experimental results. By successive etching of the samples after the irradiation, it could be shown that a layer of at least 60 μm of the samples has to be removed to get r…

Magnesium recovery from exhausted brine

2015

Mg and MgCO3 are among the 20 EU critical raw materials. Interestingly, Mg can be found at very high concentration in brines generated as waste stream from salt works. Literature works have demonstrated the feasibility of Mg extraction from brines [1–3] by reactive precipitation, for the production of Mg(OH)2. Here we present an overview of the experimental campaigns carried out using exhausted brine from real salt works (Italy) to produce Mg(OH)2 with high purity and conversion. Lab – and pilot-scale batch and semi-continuous CSTR crystallisers were developed and tested, eventually leading to a continuous process by a quasi-PFR pilot reactor. Different alkaline solutions have been adopted …

Solvent directs the dimensionality of Cu-dicyanoimidazoles

2022

In this paper, we report one-pot reactions of the same reactants 4,5-dicyanoimidazole and CuI in different solvents. In pure MeCN, the reaction resulted in previously reported MOF structure [Cu(4,5-dicyanoimidazole)]n.(MeCN)0.5n (1). On the other hand, when MeCN/MeOH solvent mixture was used, a new coordination polymer [Cu(4,5-dicyanoimidazole)(MeCN)(CuI)]n (2) was formed. The crystallization yielded very different structures as determined by X-ray crystallography. In 1, the solvent molecule acetonitrile occupies the MOF pores via weak interactions, but in 2 it is coordinated to the metal center. Computational DFT calculations and topological charge density analysis were utilized to explore…

Degradation study of XVIII century graffiti on the walls of Chiaramonte Palace (Palermo, Italy)

2010

A systematic investigation of the original materials and the degradation phenomena induced by soluble salts on the wall matrix and on the graffiti of the Inquisition jails of Chiaramonte Palace in Palermo (Italy) was carried out. Built in the XIV century, Chiaramonte Palace was used as Inquisition court during the XV–XVI centuries. The ancient graffiti, recently discovered, represent a unique historical witness of the prisoners that lived during that terrible period. In order to study the nature, the amount and the distribution of the salts in the masonry, stone materials sampled at different depth from the wall matrix and saline efflorescences were analysed. Different physical techniques w…

Study of the effects of salt crystallisation on degradation of limestone rocks

2013

Salt crystallization is widely recognized as a cause of deterioration of porous building materials. In particular, the crystallization pressure of salt crystals growing in confined pores is found to be the main cause for damage. The aim of this study is to better understand the degradation of porous rocks induced by salt crystallisation and correlate such processes with the intrinsic characteristics of materials. With this intend, an experimental salt weathering simulation has been carried out on two limestones widely used in the Baroque architecture of eastern Sicily. A systematic approach including petrographic, porosimetric and colorimetric analyses, was used to evaluate the correlation …

Magnesium recovery from concentrated brines

2014

Improving the material quality of silicon ingots by aluminum gettering during crystal growth

2016

We present a method for the purification of silicon ingots during the crystallization process that reduces significantly the width of the low charge carrier lifetime region at the ingot top. The back-diffusion of impurities from the ingot top is suppressed by adding a small amount of pure aluminum into the silicon melt right at the end of the solidification. We study the aluminum gettering effect by instrumental neutron activation analysis (INAA) and Fei imaging. Furthermore, we present a model for aluminum gettering of Fe in the silicon ingot that is in agreement with literature data for aluminum gettering at lower temperature. The distribution of iron in the ingots with and without alumin…

Challenges in preparing for Environmental Technology Verification in a demonstration project: A case study of three innovative water treatment techno…

2022

The European Union's Environmental Technology Verification (ETV) program aims to foster innovative environmental technologies to reach the market and reassure potential users. This paper presents an investigation of using ETV for three technologies, being developed within the EU Zero Brine research and innovation project. The technologies were designed to recover high quality water, salts and minerals from brine solutions. The technologies in focus are the forward feed MED evaporator, the Multi Feed - Plug Flow Reactor Crystalliser and Eutectic Freeze Crystallization. The study sought to understand the challenges of the ETV process, the readiness and eligibility of technologies, and possibl…

Reactive crystallisation process for magnesium recovery from concentrated brines

2014

Seawater brines, generated either by natural or anthropic processes, often cause significant environmental issues related to their disposal. A clear example is the case of brines from desalination plants, which can have severe environmental impacts on the receiving water body. On the other side, brines can represent a rich and appealing source of raw materials, especially when they are very concentrated, as it happens with bitterns (i.e. exhausted brines) produced in saltworks. In particular, magnesium concentration can reach values up to 30-40 kg/m3 of brine, which is 20-30 times that of typical seawater. An experimental campaign has been carried out in the present work for assessing the p…

Implementation of a global P-recovery system in urban wastewater treatment plants

2019

[EN] Current wastewater treatment plants (WWTPs) paradigm is moving towards the so-called water resource recovery facilities in which sewage is considered a source of valuable resources. In particular, urban WWTPs are crucial systems to enhance phosphorus (P) recycling. This paper evaluates the implementation of a P-recovery system in Calahorra WWTP combining the operation of a new sludge line configuration coupled to a struvite crystallisation reactor at demonstration-scale. This new configuration consisted in the elutriation in the gravity thickener of the mixed sludge contained in the mixing chamber in order to reduce the phosphate load to the anaerobic digestion. The results indicated t…