Search results for "reactors"
showing 10 items of 299 documents
Bacterial community analysis of a gas-phase biotrickling filter for biogas mimics desulfurization through the rRNA approach
2010
Abstract The bacterial composition of a lab-scale biotrickling filter (BTF) treating high loads of H 2 S was investigated by the rRNA approach. Two 16S rRNA gene clone libraries were established 42 and 189 d after reactor startup, while fluorescent in-situ hybridization (FISH) with DNA probes was performed throughout 260 d of reactor operation. Diversity, community structure and metamorphosis were studied from reactor startup to fully-established pseudo-steady state operation at near neutral pH and at an inlet H 2 S concentration of 2000 ppmv (load of 55.6 g H 2 S m −3 h −1 ). In addition, FISH was used for assessing the spatial distribution of sulfur-oxidizing bacteria (SOB) along the len…
The effect of organic loading rate and retention time on hydrogen production from a methanogenic CSTR.
2011
Abstract The possibility of shifting a methanogenic process for hydrogen production by changing the process parameters viz., organic loading rate (OLR) and hydraulic retention time (HRT) was evaluated. At first, two parallel semi-continuously fed continuously stirred tank reactors (CSTR) were operated as methanogenic reactors (M1 and M2) for 78 days. Results showed that a methane yield of 198–218 L/kg volatile solids fed (VS fed ) was obtained when fed with grass silage at an OLR of 2 kgVS/m 3 /d and HRT of 30 days. After 78 days of operation, hydrogen production was induced in M2 by increasing the OLR from 2 to 10 kgVS/m 3 /d and shortening the HRT from 30 to 6 days. The highest H 2 yield …
Anaerobic on-site treatment of black water and dairy parlour wastewater in UASB-septic tanks at low temperatures.
2004
Anaerobic on-site treatment of synthetic black water (BW) and dairy parlour wastewater (DPWW) was studied in two-phased upflow anaerobic sludge blanket (UASB)-septic tanks at low temperatures (10-20 degrees C). At all temperatures, total chemical oxygen demand (COD(t)) removal was above 90% with BW and above 80% with DPWW and removal of total suspended solids (TSS) above 90% with both wastewaters. Moreover, dissolved COD (COD(dis)) removal was approx. 70% with both wastewaters indicating good biological activity of the sludges. With BW, a single-phased reactor was found sufficient for good COD removals, while with DPWW, a two-phased process was required. Temperature optimum of reactor sludg…
Global sensitivity and uncertainty analysis of a microalgae model for wastewater treatment.
2022
The results of a global sensitivity and uncertainty analysis of a microalgae model applied to a Membrane Photobioreactor (MPBR) pilot plant were assessed. The main goals of this study were: (I) to identify the sensitivity factors of the model through the Morris screening method, i.e. the most influential factors; (II) to calibrate the influential factors online or offline; and (III) to assess the model's uncertainty. Four experimental periods were evaluated, which encompassed a wide range of environmental and operational conditions. Eleven influential factors (e.g. maximum specific growth rate, light intensity and maximum temperature) were identified in the model from a set of 34 kinetic pa…
Producing high-strength liquor from mesophilic batch acidification of chicken manure.
2015
This report describes the results from anaerobic batch acidification of chicken manure as a mono-substrate studied under mesophilic conditions. The manure was diluted with tap water to prevent methane formation during acidification and to improve mixing conditions by reducing fluid viscosity; no anaerobic digester sludge has been added as an inoculum. Highest acidification rates were measured at concentrations of 10 gVS L−1 and 20 gVS L−1; the pH value remained high (pH 6.9–7.9) throughout the test duration and unexpected fast methane formation was observed in every single batch. At substrate concentrations of 10 gVS L−1 there was a remarkable methane formation representing a value of 82% …
Hybrid activated sludge/biofilm process for the treatment of municipal wastewater in a cold climate region: a case study.
2011
A hybrid activated sludge/biofilm process was investigated for wastewater treatment in a cold climate region. This process, which contains both suspended biomass and biofilm, usually referred as IFAS process, is created by introducing plastic elements as biofilm carrier media into a conventional activated sludge reactor. In the present study, a hybrid process, composed of an activated sludge and a moving bed biofilm reactor was used. The aim of this paper has been to investigate the performances of a hybrid process, and in particular to gain insight the nitrification process, when operated at relatively low MLSS SRT and low temperatures. The results of a pilot-scale study carried out at the…
Co-digestion of sewage sludge and sterilized solid slaughterhouse waste: Methane production efficiency and process limitations
2012
The rendering product of Category 2 and 3 Animal By-Products is known as sterilized mass (SM) and it is mainly composed of fat and proteins, making it interesting substrate for anaerobic digestion. Batch and semi-continuous laboratory experiments were carried out to investigate the effect of SM addition in co-digestion with sewage sludge on methane production and possible process limitations. Results showed that SM addition in the feed mixture up to 5% (w/w), corresponding to 68.1% of the organic loading, increased methane production 5.7 times, without any indication of process inhibition. Further increase of SM addition at 7.5% (w/w) caused methane production decrease and volatile solids r…
Co-digestion of energy crops and industrial confectionery by-products with cow manure: batch-scale and farm-scale evaluation.
2002
The possible co-digestion of energy crops and industrial confectionery by-products with cow manure was evaluated firstly, through long-term batch experiments and secondly, in a farm-scale digester. In batch assays, digestion with mesophilically digested cow manure as inoculum resulted in specific methane yields (m3 kg−1 VSadded waste) of 0.35 for grass hay (particle size <1.0 cm); 0.26 for oats (0.5 cm) and 0.21 for clover (2.0 cm) harvested at vegetative stage and 0.14 (2.0 cm) for clover harvested at flowering stage. Specific methane yields (m3 kg−1 VSadded waste) for confectionery by-products were 0.37 for chocolate, 0.39 for black candy and 0.32 for confectionery raw material. Ou…
Evanescent wave-initiated photopolymerisation as a new way to create monolithic open-tubular capillary columns: use as enzymatic microreactor for on-…
2010
Evanescent wave-initiated photopolymerisation in an optically wave guiding PTFE-coated fused silica capillary using light-emitting diode as a light source, is established here as a way to fabricate monolithic porous layer open-tubular capillary columns with a potential in capillary separation methods; application of the obtained open-tubular columns as enzymatic microreactors for on-line protein digestion is demonstrated.