0000000000011675
AUTHOR
Franck Berger
Detection of lung cancer bio-markers in human breath using a micro-fabricated air analyzer
International audience; The analysis of volatile organic compounds (VOCs) that are linked to lung cancer is a very promising way in medical diagnostics because it is non-invasive and potentially inexpensive. In that sense, a silicon micro-analytical platform consisting of a three-dimensional micro-preconcentrator coupled to a silicon spiral gas chromatographic micro-column was built. A metal oxide-based gas sensor acted as a miniaturized gas detector. This system allowed selective detection of VOCs at the sub-ppm level. The present study is focused first on the chromatographic air analyzer fabrication and second on the selection of an appropriate adsorbent. Various adsorbents such as activa…
Characterization of materials toward toluene traces detection for air quality monitoring and lung cancer diagnosis
International audience; The aim of this work was to identify a nanoporous material able to trap toluene traces in order to develop a gas detection device for indoor air quality monitoring or biomedical diagnosis. A set of various adsorbents such as zeolites and activated carbon microspheres was studied here. First a detailed characterization of their porous properties was performed by nitrogen adsorption. Then adsorption of toluene and other interfering compounds which can selectively adsorbed with it, such as water and carbon dioxide, was studied in order to select the most suitable material. Results revealed that the activatedcarbon microspheres W5 and the zeolite NaY, which exhibit high …
Terpyridine-based metallopolymer thin films as active layer in ammonia sensor device
International audience; A metal-containing polymer has been prepared by electropolymerization of an homoleptic Ru(II)-terpyridine complex bearing pyrrole heterocycles. The polymer is obtained as a thinfilm at the surface ofelectrodes, and has been characterized by electrochemical measurements, XPS and microscopy. It hasbeen shown that this polymer acts as an active gas sensitive layer since it enables the detection of anammonia gasflow through layer’s resistivity measurements.
Chromatographic Air Analyzer Microsystem for the Selective and Sensitive Detection of Explosive-related Compounds
Abstract The detection of explosives and explosive-related compounds is of major importance for the monitoring of explosive- contaminated sites. Current methods need to become cheaper and portable while maintaining a high sensitivity and selectivity level. In that sense, a silicon micro-analytical platform consisting of a three-dimensional micro-preconcentrator based on a hydrophobic zeolite, coupled to a silicon spiral micro-column was built. A chemical gas sensor acted as a miniaturized gas detector. This system allowed selective detection of orthonitrotoluene (ONT), an explosive-related compound at the sub-ppm level in the presence of toluene and moisture.
Development of a micro-analytical prototype for selective trace detection of orthonitrotoluene
Abstract A silicon micro-analytical platform consisting of a micro-preconcentrator based on a hydrophobic zeolite, coupled to a silicon spiral micro-column was built. A chemical gas sensor acted as a miniaturized gas detector. This system allowed selective detection of orthonitrotoluene (ONT), an explosive-related compound at the sub-ppm level (365 ppb) in the presence of toluene and moisture.
Detection and quantification of lung cancer biomarkers by a micro-analytical device using a single metal oxide-based gas sensor
International audience; The analysis of exhaled volatile organic compounds (VOCs) related to lung cancer is a very promising wayin medical diagnosis because it is non-invasive and much less expensive than traditional medical analysisused so far. In that sense, a silicon micro-analytical platform consisting of a micro-preconcentrator cou-pled to a silicon spiral gas chromatographic micro-column was built, and a metal oxide-based gas sensorwas used as a miniaturized gas detector. This micro-fabricated device was successfully tested to selec-tively detect low concentrations of VOCs considered as lung cancer biomarkers, within a few minuteseven in presence of high concentrations of water vapor …
Benzene monitoring by micro-machined sensors with SnO2 layer obtained by using micro-droplet deposition technique
International audience; SnO2 thin layers were deposited by the way of the micro-droplet technique. The sensor substrate consisted of a thin membrane developed on oxidised silicon wafer. The sensing layers were deposited by means of the micro-droplet technique into thin layers of about 100 nm. Such devices were tested for benzene detection. The obtained results showed a very high sensitivity for this chemical compound since 500 ppb were detected. The results presented in this paper were not focused on the reactional mechanism of benzene detection but rather on the development of a cheap and sensitive sensor using sol-gel and micro-droplet processes. Since these layers were elaborated using s…
Novel Porous Carbon Material for the Detection of Traces of Volatile Organic Compounds in Indoor Air
International audience; A highly sensitive and selective silicon-based microanalytical prototype was used to identify a few ppb of volatile organic compounds (VOCs) in indoor air. Herein, a new nonactivated tannin-derived carbon synthesized by an environmentally friendly method, DM2C, a MIL-101(Cr) MOF, and a DaY zeolite were selected for the preconcentration of BTEX compounds (i.e., benzene, toluene, ethylbenzene, and xylenes). Integrating a small amount of these nanoporous solids inside a miniaturized preconcentration unit led to excellent preconcentration performance. By taking advantage of the high adsorption−desorption capacities of the DM2C adsorbent, concentrations as low as 23.5, 30…
Elaboration of ammonia gas sensors based on electrodeposited polypyrrole - cobalt phthalocyanine hybrid films
The electrochemical incorporation of a sulfonated cobalt phthalocyanine (sCoPc) in conducting polypyrrole (PPy) was done, in the presence or absence of LiClO4, in order to use the resulting hybrid material for the sensing of ammonia. After electrochemical deposition, the morphological features and structural properties of polypyrrole/phthalocyanine hybrid films were investigated and compared to those of polypyrrole films. A gas sensor consisting in platinum microelectrodes arrays was fabricated using silicon microtechnologies, and the polypyrrole and polypyrrole/phthalocyanine films were electrochemically deposited on the platinum microelectrodes arrays of this gas sensor. When exposed to a…
Selection and characterization of adsorbents for the analysis of an explosive-related molecule traces in the air
International audience; This study is focused on the development of a 3D micro-preconcentrator for a sensitive analysis of an explosive-related compound: orthonitrotoluene (ONT). A set of potentially efficient adsorbents for the pre-concentration of ONT was investigated here. An in-depth characterization of their textural properties was carried out in order to better understand their adsorption behavior toward the target analyte. More particularly, this study allowed highlighting the interesting adsorption features of a hydrophobic zeolite and a porous activated carbon in relation to their preconcentration performances toward ONT at the ppb level. Moreover, we found a difference in the adso…